Skip to main content

ORIGINAL RESEARCH article

Front. Microbiol., 28 November 2017
Sec. Food Microbiology
This article is part of the Research Topic Foodborne Pathogens: Hygiene and Safety View all 49 articles

Food Grade Pimenta Leaf Essential Oil Reduces the Attachment of Salmonella enterica Heidelberg (2011 Ground Turkey Outbreak Isolate) on to Turkey Skin

  • Department of Animal Science, University of Minnesota, Saint Paul, MN, United States

Salmonella attached to the poultry skin is a major source of carcass contamination during processing. Once attached to the poultry skin, it is difficult to detach and inactivate Salmonella by commonly used antimicrobial agents since the pathogen is entrapped deeply in the feather follicles and the crevices on the skin. Essential oils could be natural, safe, and effective alternatives to synthetic antimicrobial agents during commercial and organic processing setup. The present study evaluated the efficacy of pimenta (Pimenta officinalis Lindl.) leaf essential oil (PEO), and its nanoemulsion in reducing Salmonella Heidelberg attachment on to turkey (Meleagris gallopavo) skin during simulated scalding (65°C) and chilling (4°C) steps in poultry processing. A multidrug resistant S. Heidelberg isolate from the 2011 ground turkey outbreak in the United States was used in the study. Results showed that PEO and the nanoemulsion resulted in significant reduction of S. Heidelberg attachment on turkey skin. Turkey skin samples treated with 1.0% PEO for 5 min resulted in >2 log10 CFU/sq. inch reduction of S. Heidelberg at 65 and 4°C, respectively (n = 6; P < 0.05). Similarly, skin samples treated with 1.0% pimenta nanoemulsion (PNE) for 5 min resulted in 1.5- and 1.8- log10 CFU/sq. inch reduction of S. Heidelberg at 65 and 4°C, respectively (n = 6; P < 0.05). In addition, PEO and PNE were effective in reducing S. Heidelberg on skin during short-term storage at 4 and 10°C (temperature abuse) (n = 6; P < 0.05). No Salmonella was detected in the dipping solution containing 0.5 or 1.0% PEO or PNE, whereas a substantial population of the pathogen survived in the control dipping solution. The results were validated using scanning electron -, and confocal - microscopy techniques. PEO or PNE could be utilized as an effective antimicrobial agent to reduce S. Heidelberg attachment to turkey skin during poultry processing.

Introduction

Historically, Salmonella enterica serovar Heidelberg (S. Heidelberg) has been one of the common Salmonella associated with poultry and is frequently isolated from turkeys (Foley et al., 2008; Jackson et al., 2013). Being one of the most invasive of Salmonella serotypes in humans, the pathogen has surfaced to importance causing significant economic loss to the poultry industry and public health. In 2011, the consumption of contaminated ground turkey meat resulted in 136 human infections in 34 United States (CDC, 2011). In 2013, multidrug resistant (MDR) S. Heidelberg infections were linked to contaminated poultry products from a commercial processor in California (CDC, 2014a). Another outbreak caused by S. Heidelberg, including its MDR clones, was reported from a Tennessee correctional facility linked to consumption of contaminated poultry meat (CDC, 2014b). More recently, S. Heidelberg was ranked third among the most common etiological agents of human salmonellosis in the United States (CDC, 2013) and is currently an urgent threat to the United States food supply due to their high antibiotic resistance (AR) potential (Folster et al., 2012a,b; Shah et al., 2017)

Turkeys can harbor S. Heidelberg in their cecum without showing clinical disease (Poppe et al., 2005; Nair et al., 2016). The excretion of the pathogen through droppings can contaminate farm, and faulty evisceration step during processing could result in the contamination of turkey carcasses with S. Heidelberg (WHO, 2009). Salmonella attached to the carcass skin is a major source of poultry meat contamination during processing (Kim et al., 1996; Carrasco et al., 2012). During the scalding step, the turkey carcasses are immersed in water at 59 to 63°C for 50 to 125 s (FSIS, 2010) to up to a reported 65°C (Logue et al., 2003) to loosen the hair follicles (Carrasco et al., 2012). This step is considered as the first and critical step where a high likelihood of cross-contamination with pathogenic bacteria, including Salmonella, could occur (Russell, 2008; Carrasco et al., 2012). During chilling, the carcasses are immersed in cold water (4.4°C) where the chances of cross-contamination of carcasses with Salmonella is high (Nagel et al., 2013). The water uptake and swelling of the poultry skin during immersion chilling also expose deep channels and crevices on the skin, making the conditions favorable for bacterial attachment (Kim et al., 1996). The oily nature of poultry skin, penetration of Salmonella into the feather follicles, entrapment of Salmonella in the skin crevices, and the presence of high organic load on skin surface during scalding and chilling may reduce the effectiveness of chlorine and other commercially used synthetic disinfectants (Lillard, 1990; Kim et al., 1996; Yang et al., 2001; Nchez et al., 2002; Nagel et al., 2013). Along with these factors, various genetic mechanisms enable Salmonella to attach tightly to the skin of poultry carcasses (Salehi et al., 2017).

Recently, there is a tremendous interest in using natural antimicrobials as an alternative to synthetic chemicals against pathogens during food production (Burt, 2004; Lanciotti et al., 2004; Amalaradjou et al., 2010; Kollanoor Johny et al., 2010; Nair et al., 2015; Surendran Nair et al., 2016; Surendran-Nair et al., 2016). Among the emerging and widely researched alternatives, essential oils (EO) or their components are reported effective against foodborne pathogens such as Salmonella, Campylobacter, and Escherichia coli O157 in vitro and in vivo (Kollanoor Johny et al., 2008; Amalaradjou et al., 2010; Kollanoor-Johny et al., 2012a,b; Nair et al., 2014, 2015). The United States Food and Drug Administration (USFDA) has approved the use of selected EOs in food matrices (FDA, 2016) and therefore, their efficacy could be evaluated as safe and natural alternatives in commercial and organic poultry production systems (GPO, 2017). The use of EOs is also advantageous since they possess multiple active chemical sites to counteract pathogens using different mechanisms reducing the potential for the development of antimicrobial resistance against EOs (Venkitanarayanan et al., 2013; Surendran Nair et al., 2017).

Pimenta essential oil (PEO), commonly known as allspice oil, is extracted from the leaves of Pimenta officinalis Lindl. and is approved as Generally Recognized As Safe (GRAS; CFR-Title 21: Part 182, Sec. 182.20) compound by the Food and Drug Administration (FDA, 2016). The major component of PEO is eugenol (>80%) (Suzuki et al., 2014). The PEO possesses antimicrobial activity against several microorganisms such as Staphylococcus epidermidis, Proteus hauseri, Micrococcus yunnanensis, and Corynebacterium xerosis (Suzuki et al., 2014). PEO also possesses in vitro antimicrobial activity against Listeria monocytogenes (Aureli et al., 1992). However, no studies have been conducted to explore the efficacy of PEO against Salmonella in poultry or poultry products. Therefore, the current study evaluated the efficacy of PEO and its nanoemulsion (PNE) on S. Heidelberg attachment on turkey skin. The specific objectives of the study were (1) to investigate the effect of PEO or PNE on reducing S. Heidelberg attachment (high inoculum and low inoculum) to turkey skin at 4 or 65°C, (2) to determine the effect of PEO or PNE on reducing S. Heidelberg (low inoculum) survival on skin during storage for 2 days at 4 or 10°C, and (3) to illustrate the effect of PEO on S. Heidelberg (low inoculum) attachment to the turkey skin using confocal microscopy (CM) and scanning electron microscopy (SEM).

Materials and Methods

All biosafety procedures in Dr. Kollanoor Johny’s laboratory are approved by the Institutional Biosafety Committee at the University of Minnesota.

Bacterial Strain and Growth Conditions

An MDR S. Heidelberg isolate from the 2011 ground turkey outbreak in the United States (kindly donated by Dr. Irene Hanning, College of Genome Sciences and Technology, University of Tennessee and Dr. Venkitanarayanan, University of Connecticut), was used for the study. Working cultures of S. Heidelberg was prepared from the glycerol stock cultures stored at -80°C. S. Heidelberg was made resistant to 50 μg/ml nalidixic acid sodium salt (NA; CAS. no. 3374-05-8, Alfa Aesar, Haverhill, MA, United States) for selective enumeration. The growth of S. Heidelberg (overnight culture) in tryptic soy broth (TSB; catalog no.C7141, Criterion, Hardy Diagnostics, Santa Maria, CA, United States) was determined on xylose lysine desoxycholate agar plates (XLD; catalog no. C 7322, Criterion, Hardy Diagnostics, Santa Maria, CA, United States) containing, 50 μg/ml NA and incubating at 37°C for 24 h. Then, final inoculum levels of 4 and 7 log10 CFU/ml were prepared from overnight broth culture (∼9 log10 CFU/ml) after centrifugation (3,600 × g, 15 min, 4°C) (Allegra X-14 R centrifuge, Beckman Coulter; 5350 Lakeview Parkway S Drive, Indianapolis, IN, United States) and suspending the pellets in sterile phosphate-buffered saline (PBS; pH 7.2) (Kollanoor-Johny et al., 2012a).

Turkey Skin Preparation

Turkey drumsticks purchased from a local retail store were used for the study. The skin was separated from underlying muscles using a sterile scalpel, and 1 inch × 1 inch skin portions were exposed to UV light for 5 min to kill the background microbial flora before the application of S. Heidelberg on the skin surface (Kim et al., 1996).

Inoculation of S. Heidelberg on Turkey Skin Surface

The skin samples were dipped in 100 ml PBS containing 4 and 7 log10 CFU/ml S. Heidelberg for 20 min. Skin samples were stored at room temperature in a biosafety cabinet for 1 h for Salmonella attachment. Unattached and loose Salmonella were removed by immersing the skin samples in sterile PBS for 5 min. Non-inoculated skin samples dipped in sterile PBS were used as negative controls (Kim et al., 1996; Tamblyn and Conner, 1997; Tamblyn et al., 1997).

PEO, PNE, and Determination of Particle Size of PNE

PEO (≥99%; Natural, Food Grade; PCcode: 1002115007; Product: W290106-100G-K; Lot# MKBS7421V) was purchased from Sigma–Aldrich (St. Louis, MO, United States). PEO was mixed (by vortexing) in DI water for 30 s to prepare desired concentrations (0.5 and 1.0% v/v) for treating the turkey skin in all the experiments. PNE was prepared using high energy sonication technique as described previously (Ghosh et al., 2013; Bhargava et al., 2015). Briefly, PEO was emulsified in DI water adding tween 80 (2:1) and homogenized under high energy sonication (750 W) using a sonicator (Soniprep 450). The procedure was continued for 20 min with short intervals in an ice containing chamber to reduce the heat generation during sonication and to avoid the evaporative loss of the oil. The stability and particle size of PNE were determined using dynamic light scattering method after storing PNE at room temperature for 7 days (Bhargava et al., 2015).

Dip Treatment of PEO or PNE on S. Heidelberg Attached to Turkey Skin at 65°C

PEO or PNE at concentrations of 0.5 and 1.0% (v/v) were freshly prepared in sterile DI water by vortexing for 30 s, and used in the study by maintaining the temperature at 65°C using a hot water bath (Model: 89032-226, VWR international, 1310 Goshen parkway, PA, United States). The temperature of the treatment water was set at 65°C to simulate the scalding step in poultry processing, and the temperature was monitored using a thermocouple for constancy. Each skin sample was inoculated with S. Heidelberg (4 log10 CFU/sq. inch or 7 log10 CFU/sq. inch) and separately dipped in 0, 0.5 or 1% (v/v) of PEO or PNE for the 30 s, 3 min, or 5 min. The skin samples were homogenized immediately after the dip treatment in fresh 10 ml PBS, and S. Heidelberg survival rate was determined. An industry control (chlorine, 50 ppm) and a solvent control (tween 80, 1%) were also tested with the lower inoculum level of S. Heidelberg at 65°C following the same protocol as detailed above to determine if these treatments had any effect on the pathogen populations.

Dip Treatment of PEO or PNE on Skin Attached S. Heidelberg at Chilling Temperature

Concentrations of PEO or PNE at 0.5 and 1.0% (v/v) were freshly prepared in DI water by vortexing for 30 s, and used in the study by maintaining the temperature at 4°C. The temperature of the treatment water was maintained at 4°C to simulate chilling in poultry processing. Each skin sample was inoculated with S. Heidelberg (4 log10 CFU/sq. inch or 7 log10 CFU/sq. inch) and separately dipped in 0, 0.5, or 1% (v/v) of PEO or PNE for the 30 s, 3 min, or 5 min. Then skin samples were homogenized immediately after the dip treatment in fresh 10 ml PBS, and S. Heidelberg attachment was determined. An industry control (chlorine, 50 ppm) and a solvent control (tween 80, 1%) were also tested with the lower inoculum level of S. Heidelberg at 4°C following the same protocol as detailed above to determine if these treatments had any effect on the pathogen populations.

Dip Treatment of PEO or PNE on S. Heidelberg Survival on Skin Surface during Storage at Chilling and Abuse Temperature

The PEO or PNE treatments at 1% (v/v) was prepared in sterile DI water by vortexing for 30 s, at 4°C and used for dip treating skin samples; S. Heidelberg inoculated (4 log10 CFU/sq. inch) and non-inoculated (control) skin samples for 5 min under chilling temperature were kept. Then the (non-dripping) samples were packaged under aerobic conditions and stored at 4 or 10°C for 48 h (FSIS, 2002; Ingham et al., 2007). S. Heidelberg attachment was determined by sampling at 0, 2, 24, and 48 h of storage after PEO and PNE treatments.

Microbiological Analysis

The surviving S. Heidelberg attached on the skin after PEO or PNE treatments were determined by enumeration. The skin samples were homogenized with 10 ml sterile PBS in a stomacher (100/125V, 50/60Hz; Neutec Group Inc., 200 Central Ave, Farmingdale, NY, United States) for 2 min at 200 rpm. Then the sample homogenates were serially diluted 10-folds, and a volume of 100 μl from appropriate dilutions was surface plated on XLD containing 50 μg/ml NA. The surviving S. Heidelberg were enumerated after 24 h incubation at 37°C (Kollanoor-Johny et al., 2012a). A 100 μl of the dipping solution after all the treatments were directly surface plated on XLD + NA plates to determine any surviving pathogen populations in the dipping solution. Further, 1 ml of the dipping solution was enriched in 10 ml of selenite cysteine broth (Criterion, Hardy Diagnostics, Santa Maria, CA, United States), incubated for 12 h and streaked on XLD + NA plates for detection of surviving bacteria if any.

CM of Turkey Skin Treated with PEO

Turkey skin (1 inch × 1 inch) portions were inoculated with 4 log10 CFU/sq. inch S. Heidelberg. Skin samples were dip treated in 1% PEO for 5 min at 4°C. Immediately after treatments, the skin samples were stained with L7012 LIVE/DEAD® BacLight Bacterial Viability Kit (Catalog number: L7012, Thermo Fisher Scientific, Waltham, MA, United States) as described previously (Seo and Frank, 1999). Briefly, the inoculated and non-inoculated skin samples with or without treatment with PEO were immersed in a solution containing equal volume of SYTO® 9 green-fluorescent nucleic acid stain (Catalog number: L7012, Thermo Fisher Scientific, Waltham, MA, United States) and propidium iodide Catalog number: L7012, Thermo Fisher Scientific, Waltham, MA, United States) red-fluorescent nucleic acid stain. The SYTO® 9 dye stains both live and dead cells. However, propidium iodide penetrates only through damaged cell membranes (dead bacteria) and masks the intensity of SYTO® 9 dye when both dyes are present. Therefore, live and dead bacteria appear as green and red, respectively. The skin samples were examined for live and dead bacteria under a confocal microscope (Nikon A1 spectral confocal microscope, University of Minnesota Imaging Center) after incubating at room temperature for 15 min. Non-inoculated skin samples dipped in sterile DI water or PEO served as negative controls. Similarly, S. Heidelberg inoculated skin samples dipped in sterile DI water for 5 min were included as positive controls.

SEM of Turkey Skin Treated with PEO

Turkey skin samples (1 inch × 1 inch) inoculated with S. Heidelberg (4 log10 CFU/sq. inch) was dipped in 1% PEO for 5 min at 4°C. Non-inoculated skin samples dipped in sterile DI water or PEOs were used as negative controls. S. Heidelberg dipped in sterile DI water for 5 min served as S. Heidelberg controls. Sample preparation for electron microscopy was conducted as previously described with some modifications (Lee et al., 2014). Briefly, immediately after each treatment, the skin samples were stored in primary fixative [3% paraformaldehyde, 1.5% glutaraldehyde, and 2.5% sucrose in 0.1 M sodium cacodylate buffer with 5mM calcium chloride and 5mM magnesium chloride (pH 7.4)] for 12 h. Then the samples were fixed in 2% osmium tetroxide and 0.1 M sodium cacodylate buffer for 12 h. Then the samples were washed in ultrapure water (NANOpure Infinity®; Barnstead/Thermo Fisher Scientific; Waltham, MD, United States) and dehydrated by ascending grades of ethanol series. Samples were processed in a critical point dryer (Autosamdri-814; Tousimis; Rockville, MD, United States) and mounted on aluminum stubs, sputter-coated with gold-palladium, and observed using a scanning electron microscope (S3500N; Hitachi High Technologies America, Inc.; Schaumberg, Illinois; University of Minnesota Imaging Center) at an accelerating voltage of 5.00 kV.

Statistical Analysis

A completely randomized design was used to analyze the effect of PEO and PNE treatments on S. Heidelberg in all experiments. Each skin sample served as the experimental unit. The number of S. Heidelberg colonies were logarithmically transformed before analysis to achieve homogeneity of variance (Byrd et al., 2003). The detection limit of S. Heidelberg was set at 1.0 log10 CFU/ml on XLD plates. The samples from which no bacteria were recovered after spread plating, but positive after enrichment, were assumed a value of 0.95 for analysis (9 CFU/ml) (Seo et al., 2000; Young et al., 2007). The data were analyzed using the PROC MIXED procedure of SAS (version 9.3) (SAS Institute, 2004). Differences among the least square means were detected using Fisher’s least significant difference test. A P value of <0.05 was considered statistically significant.

Results and Discussion

Effect of PEO or PNE against S. Heidelberg Attachment on Turkey Skin at Scalding Temperature (65°C)

Scalding is the step where the feather follicle is loosened for feather removal (picking) (Carrasco et al., 2012; FSIS, 2015). Scalding tanks are a potential area for carcass cross-contamination with pathogens such as Salmonella and Campylobacter (FSIS, 2015). Cross-contamination can lead to the attachment of Salmonella to the skin surface eventually making it hard to detach the pathogens with commonly used antimicrobial agents (Lillard, 1990; Kim et al., 1996; Yang et al., 2001; Nchez et al., 2002; Nagel et al., 2013).

In the current study, two levels of initial inocula were tested: a higher inoculum level of 7 log10 CFU/sq. inch, and a lower inoculation level of 4 log10 CFU/sq. inch. The application of PEO resulted in a significant reduction of S. Heidelberg attachment on turkey skin at scalding temperature when a high-level inoculum of S. Heidelberg was used (Figure 1). The PEO treatment at a concentration of 0.5% resulted in 1.13 log10 CFU/sq. inch reduction of S. Heidelberg after 5 min dip treatment (P < 0.05) at 65°C, compared to the Salmonella control. Whereas, 1% PEO dip treatment resulted in 1.37, 1.57 and 2.05 log10 CFU/sq. inch reduction of S. Heidelberg in 30 s, 3 min, and 5 min, respectively at 65°C (P < 0.05) (Figure 1). The PEO treatment was also effective when a low initial inoculum of S. Heidelberg was tested and was concentration dependent (Figure 2). The PEO treatment at the lower concentration of 0.5% resulted in 0.72, 1.09, and 1.87 log10 CFU/sq. inch reduction of S. Heidelberg in 30 s, 3 min, and 5 min dip treatment, respectively at 65°C (P < 0.05) whereas, 1% PEO dip treatment resulted in 1.66, 1.87, and 2.19 log10 CFU/sq. inch reduction of S. Heidelberg in 30 s, 3 min, and 5 min (enrichment negative), respectively 65°C (P < 0.05) (Figure 2).

FIGURE 1
www.frontiersin.org

FIGURE 1. Effect of PEO against S. Heidelberg attachment on turkey skin at scalding temperature (65°C) at higher initial inoculum. S. Heidelberg (7 log10 CFU/sq. inch) inoculated skin samples were treated with 0, 0.5, or 1.0% PEO for 30 s, 3 min, or 5 min at 65°C. The skin samples were homogenized immediately after the dip treatment and the pathogen populations were determined. The treatments were significantly different at P < 0.05.

FIGURE 2
www.frontiersin.org

FIGURE 2. Effect of PEO against S. Heidelberg attachment on turkey skin at scalding temperature (65°C) at lower initial inoculum. S. Heidelberg (4 log10 CFU/sq. inch) inoculated skin samples were treated with 0, 0.5, or 1.0% PEO for 30 s, 3 min, or 5 min at 65°C. The skin samples were homogenized immediately after the dip treatment and the pathogen populations were determined. The treatments were significantly different at P < 0.05.

Chlorine is a common antimicrobial agent used in poultry processing (Sohaib et al., 2015). However, chlorine may lose its efficacy in scalding tanks due to the high organic load associated with the carcass, and the evaporative loss of the chlorine over time in the scalding tanks (FSIS, 2015). Organic acids can be used in scalding tanks. However, organic acids such as acetic, citric, lactic, malic, mandelic, propionic, or tartaric acid require a concentration of 2.0–6.0% to obtain 2 log10 CFU or more reduction of Salmonella attached to the skin of broiler carcasses (Tamblyn and Conner, 1997). In addition, previous studies reported the reduced activity of commonly used synthetic antimicrobial agents such as sodium hypochlorite, acetic acid, trisodium phosphate, and sodium metabisulfite against Salmonella attached to poultry skin, and revealed the potential of increased resistance of Salmonella to these antimicrobial treatments (Tamblyn et al., 1997). In the current study, S. Heidelberg reduction obtained with the use of 1% PEO after 5 min at the lower inoculum level tested was comparable to that of organic acids, and other USDA approved synthetic antimicrobial agents (Tamblyn et al., 1997; Tamblyn and Conner, 1997).

After exploring the efficacy of PEO at both inoculum levels, we focused on the lower inoculum (4 log10 CFU/sq. inch) to test the effect of PNE. Although the reported contamination level of Salmonella on poultry carcasses exiting the chillers is ∼ 2.0 log10 CFU/carcass (Waldroup, 1996), we increased the inoculum to 4 log10 CFU/sq. inch to avoid any potential bias in determining the efficacy of PNE treatment. The nanoemulsion of PEO (PNE) could increase the solubility and stability of PEO in water, and the fine droplet size could increase the availability of PEO (Landry et al., 2014). The peak droplet size of the prepared PNE remained in the range of 1.6–2.3 nm during a storage period of 7 days at room temperature which could indicate its increased stability in the water (Figure 3).

FIGURE 3
www.frontiersin.org

FIGURE 3. Pimenta nanoemulsion (PNE) was prepared by emulsifying PEO in DI water using tween 80 (2:1) and homogenized under high energy sonication (750 W) using a sonicator. The procedure was continued for 20 min with short intervals. The stability and particle size of PNE were determined using dynamic light scattering method after storing PNE at room temperature for 7 days.

The PNE treatment resulted in significant reduction of S. Heidelberg on the skin which was comparable to the respective concentrations of PEO at 65°C. The PNE treatment at 0.5% resulted in 1.07, 0.53 and 0.95 log10 CFU/sq. inch reduction of skin-attached S. Heidelberg after 30 s, 3 min, and 5 min dip treatment, respectively at 65°C (P < 0.05). Similarly, 1.0% PNE resulted in 1.14, 1.03, and 1.51 log10 CFU/sq. inch reductions of S. Heidelberg after 30 s, 3 min, and 5 min dip treatment, respectively at 65°C (P < 0.05; Figure 4). In the current experiment, both PEO and PNE showed similar efficacy since PEO also had small droplet size and uniform distribution on the skin surface due to the vigorous homogenization in DI water before application on the skin surface.

FIGURE 4
www.frontiersin.org

FIGURE 4. Effect of PNE against S. Heidelberg attachment on turkey skin at scalding temperature (65°C) for lower initial inoculum. S. Heidelberg (4 log10 CFU/sq. inch) inoculated skin samples were treated with 0, 0.5, or 1.0% PNE for 30 s, 3 min, or 5 min at 65°C. The skin samples were homogenized immediately after the dip treatment and the pathogen populations were determined. The treatments were significantly different at P < 0.05.

After the treatments, no S. Heidelberg was detected in the dipping solution containing PNE and PEO treatments (enrichment negative). However, a substantial population of the pathogen survived in the control dipping solution. The positive controls had 2.2-, 1.9-, and 2.3- log10 CFU/ml of S. Heidelberg after 30 s, 3 min, and 5 min dip treatments at 65°C. In addition, we conducted experiments using chlorine (50 ppm; industry control) and tween 80 (1.0%; solvent control) and found that these controls had no effect on the skin attached S. Heidelberg at 65°C compared to the Salmonella control (P > 0.05; Figure 5).

FIGURE 5
www.frontiersin.org

FIGURE 5. Effect of chlorine (50 ppm) and tween 80 (1.0%) against S. Heidelberg attachment on turkey skin at scalding temperature (65°C) for lower initial inoculum. S. Heidelberg (4 log10 CFU/sq. inch) inoculated skin samples were treated with 50 ppm chlorine or 1.0% tween 80 for 30 s, 3 min, or 5 min at 65°C. The skin samples were homogenized immediately after the dip treatment and the pathogen populations were determined.

Effect of PEO or PNE against S. Heidelberg Attachment on Turkey Skin at Chilling Temperature (4°C)

Chilling is a critical step in poultry processing where the internal temperature of the poultry carcass is reduced to 40°F (4.4°C) or below within 4–8 h of slaughtering to prevent the growth of pathogenic bacteria including Salmonella (FSIS, 2014). The cross-contamination of carcasses with Salmonella is high in chiller where the carcasses are immersed in chilling water, and the carcass exiting the chiller tank often carry a significant amount of the pathogen (Lillard, 1990; Nchez et al., 2002). In the current study, the PEO application as dip treatment at 4°C significantly reduced the attachment of S. Heidelberg on turkey skin and the reduction was concentration and contact time dependent after 5 min of exposure for higher inoculation (Figure 6). Dip treatment of PEO at 0.5 and 1% did not result in significant reduction of skin attached S. Heidelberg for a contact period of 30 s at 4°C when higher initial inoculum of S. Heidelberg was used (P > 0.05; Figure 6). However, 3- and 5- min dip treatment with PEO resulted in a significant reduction of S. Heidelberg compared to the control at both concentrations tested (P < 0.05; Figure 6).

FIGURE 6
www.frontiersin.org

FIGURE 6. Effect of PEO against S. Heidelberg attachment on turkey skin at chilling temperature (4°C) for higher initial inoculum. S. Heidelberg (7 log10 CFU/sq. inch) inoculated skin samples were treated with 0, 0.5, or 1.0% PEO for 30 s, 3 min, or 5 min at 4°C. The skin samples were homogenized immediately after the dip treatment and the pathogen populations were determined. The treatments were significantly different at P < 0.05.

The PEO treatment showed higher efficacy against S. Heidelberg at 4°C with the low initial inoculum of Salmonella (4 log10 CFU/sq. inch skin) compared to the higher inoculation (7 log10 CFU/sq. inch skin). In addition, both PEO concentrations resulted in rapid reduction of S. Heidelberg for a contact time as low as 30 s (P < 0.05; Figure 7). For the 0.5% PEO dip treatment, reduction of 0.89, 1.50, and 1.74 log10 CFU/sq. inch was obtained with 30 s, 3 min, and 5 min contact time, respectively at 4°C, compared to the controls (P < 0.05), whereas, a reduction of 1.3, 1.99, and 2.40 log10 CFU/sq. inch was obtained with 1.0% PEO after 30 s, 3 min, and 5 min dip treatment, compared to the control at 4°C (P < 0.05; Figure 7).

FIGURE 7
www.frontiersin.org

FIGURE 7. Effect of PEO against S. Heidelberg attachment on turkey skin at chilling temperature (4°C) for lower initial inoculum. S. Heidelberg (4 log10 CFU/sq. inch) inoculated skin samples were treated with 0, 0.5, or 1.0% PEO for 30 s, 3 min, or 5 min at 4°C. The skin samples were homogenized immediately after the dip treatment and the pathogen populations were determined. The treatments were significantly different at P < 0.05.

In the current study, PEO was rapidly effective against S. Heidelberg attachment on turkey skin (3 or 5 min for higher initial inoculum, and 30 s, 3 min, or 5 min for lower initial inoculum). As a usual practice, poultry carcass is immersed in the chilling tank at 4.4°C, and the antimicrobial agents get sufficient contact time to reduce Salmonella (Nagel et al., 2013). However, common antimicrobial agents including chlorine were found to be less effective against skin-attached Salmonella. Chlorine reduced less than 1.0 log10 CFU/ml of S. Typhimurium attachment on poultry skin at a concentration of 50 ppm for 50 min contact time (Yang et al., 2001). In our study, the PEO dip treatment showed similar or better/higher efficacy compared to other synthetic antimicrobial agents approved for the chilling process. For example, a common antimicrobial, sodium metabisulfite, was ineffective against firmly attached Salmonella even after 60 min immersion treatment at 0°C. In addition, acetic acid (5%) and sodium metabisulfite (1%) were ineffective against S. Typhimurium attachment on poultry skin under aforementioned chilling conditions (Tamblyn et al., 1997). Additionally, organic acids such as acetic, citric, lactic, malic, mandelic, propionic, or tartaric acid required a concentration of 4.0% or above to get at least 2 log10 reduction of S. Typhimurium attachment on poultry skin at 0°C for 60 min contact time (Tamblyn and Conner, 1997). Another antimicrobial, sodium hypochlorite, was effective against skin-attached S. Typhimurium only when used at higher concentrations such as 400 and 800 ppm for a contact time of 60 min at 0°C to result in <2 log10 CFU/ml reductions of firmly attached Salmonella on the skin surface.

In addition to the potential use of PEO in chilling tanks, it could be used for post-chill dip treatment during poultry processing since PEO dip treatment was effective rapidly against skin-attached S. Heidelberg. Post-chill dip application of antimicrobial agents is currently practiced as a part of the multiple hurdle technology along with antimicrobial interventions in the chilling tanks (Nagel et al., 2013; Nair et al., 2015). The advantage of post-chill dip application is that the carcass is in contact with the antimicrobial agent for a shorter duration (30 s) and a higher concentration of antimicrobial agent can be used without deteriorating the carcass quality. The antimicrobial agent would be more efficient since there is less organic load compared to the chilling tank (Nagel et al., 2013). In the current study, 30 s dip treatment of PEO resulted in 0.83 and 1.3 log10 CFU/sq. inch reductions of S. Heidelberg with 0.5 and 1.0% PEO, respectively at 4°C. It is comparable to the reduction achieved during post chill dip treatment using other synthetic antimicrobial agents or other EOs (Nagel et al., 2013; Nair et al., 2014, 2015). For example, 40 or 400 ppm chlorine and 1000 or 5000 ppm lysozyme resulted in less than 1 log10 CFU/ml reduction of S. Typhimurium on broiler carcass when used as post-chill dip treatment for 20 s (Nagel et al., 2013). Similarly, post chill application of carvacrol at 0.5, 1.0, or 2% for 30 s resulted in less than a log10 CFU/ml reduction of Salmonella spp. (S. Enteritidis, S. Heidelberg, and S. Typhimurium) on skinless, boneless turkey breast cutlets (Nair et al., 2014).

The PNE treatment also showed significant reduction of skin-attached S. Heidelberg at 4°C (Figure 8). Lower initial inoculum (4.0 log10 CFU/sq. inch) of S. Heidelberg was used to study the effect of PNE on skin-attached S. Heidelberg since PEO treatment showed similar or higher efficacy when used against the lower initial inoculum of S. Heidelberg. At chilling temperature, PNE at 0.5% resulted in 0.94, 1.53 and 1.47 log10 CFU/sq. inch reductions of S. Heidelberg in 30 s, 3 min, and 5 min dip treatment, respectively (P < 0.05), compared to the S. Heidelberg control. Likewise, PNE at 1% resulted in 1.51, 1.74, and 1.76 log10 CFU/sq. inch reductions of S. Heidelberg after 30 s, 3 min, and 5 min dip treatment, respectively at 4°C compared to the control (P < 0.05) (Figure 8).

FIGURE 8
www.frontiersin.org

FIGURE 8. Effect of PNE against S. Heidelberg attachment on turkey skin at chilling temperature (4°C) for lower initial inoculum. S. Heidelberg (4 log10 CFU/sq. inch) inoculated skin samples were treated with 0, 0.5, or 1.0% PNE for 30 s, 3 min, or 5 min at 4°C. The skin samples were homogenized immediately after the dip treatment and the pathogen populations were determined. The treatments were significantly different at P < 0.05.

After the treatments, no S. Heidelberg was detected in the dipping solution containing PNE and PEO treatments (enrichment negative). However, a substantial population of the pathogen survived in the control dipping solution. The positive controls had 2.5-, 2.4-, and 2.6- log10 CFU/ml of S. Heidelberg after 30 s, 3 min and 5 min dip treatments at 4°C. In addition, we conducted experiments using chlorine (50 ppm; industry control) and tween 80 (1.0%; solvent control) and found that these controls had no effect on the skin attached S. Heidelberg at 4°C compared to the Salmonella control. Chlorine treatment resulted in only 0.37 and 0.44 log10 CFU/sq. inch reductions of S. Heidelberg (P > 0.05; Figure 9) for 3 and 5 min dip treatments, respectively whereas tween 80 treatment resulted in same S. Heidelberg count as that of Salmonella control in all the three dip treatments at 4°C (P > 0.05; Figure 9).

FIGURE 9
www.frontiersin.org

FIGURE 9. Effect of chlorine (50 ppm) and tween 80 (1.0%) against S. Heidelberg attachment on turkey skin at chilling temperature (4°C) for lower initial inoculum. S. Heidelberg (4 log10 CFU/sq. inch) inoculated skin samples were treated with 50 ppm chlorine or 1.0% tween 80 for 30 s, 3 min, or 5 min at 65°C. The skin samples were homogenized immediately after the dip treatment and the pathogen populations were determined.

Effect of PEO or PNE against S. Heidelberg Attachment on Turkey Skin at 4°C and Stored for 48 h at 4°C and 10°C

The PEO treatment at 1% applied for 5 min at 4°C showed a higher reduction of S. Heidelberg attachment on turkey skin (Figure 7). Therefore, the same combination was used for determining the efficacy of PEO or PNE treatments against S. Heidelberg attachment on turkey skin for 48 h storage at 4°C (Figure 10A) and 10°C (Figure 10B; abuse temperature). The PEO treatment (1.0%) resulted in 2.27, 1.63, and 1.83 log10 CFU/sq. inch reduction of S. Heidelberg after 2, 24 and 48 h of storage at 4°C (P < 0.05) (Figure 10A). The skin samples were also stored at 10°C to determine S. Heidelberg attachment at abuse temperature during refrigerated storage (FSIS, 2002). S. Heidelberg multiplied during 10°C storage in the S. Heidelberg controls. However, 1% PEO dip treatment for 5 min significantly reduced S. Heidelberg growth and multiplication on the skin after 2, 24, and 48 h of storage at 10°C (P < 0.05; Figure 10B).

FIGURE 10
www.frontiersin.org

FIGURE 10. (A) Effect of PEO against S. Heidelberg attachment on turkey skin at chilling temperature (4°C) and storage at 4°C for 48 h. S. Heidelberg (4 log10 CFU/sq. inch) inoculated skin samples were treated with 0 or 1.0% PEO for 5 min at 4°C. The samples were packaged under aerobic conditions and stored at 4°C. S. Heidelberg attachment was determined by sampling at 0, 2, 24, and 48 h of storage after PEO treatments. The treatments were significantly different at P < 0.05. (B) Effect of PEO against S. Heidelberg attachment on turkey skin at chilling temperature (4°C) and storage at 10°C for 48 h. S. Heidelberg (4 log10 CFU/sq. inch) inoculated skin samples were treated with 0 or 1.0% PEO for 5 min at 4°C. The samples were packaged under aerobic conditions and stored at 10°C. S. Heidelberg attachment was determined by sampling at 0, 2, 24, and 48 h of storage after PEO treatments. The treatments were significantly different at P < 0.05.

The PNE (1.0%) treatment was also effective in reducing S. Heidelberg attachment on turkey skin at 4 and 10°C; the efficacy was comparable to the 1.0% PEO treatment for 5 min under similar storage conditions. The PNE treatment resulted in significant reduction in S. Heidelberg attachment after 2, 24 and 48 h of storage at 4°C (P < 0.05; Figure 11A). Likewise, PNE resulted in a similar reduction in S. Heidelberg populations after storage at 10°C (P < 0.05; Figure 11B). Therefore, the results of the present study indicate that PEO and PNE treatments are effective in reducing S. Heidelberg attachment on turkey skin when stored at 4°C for 48 h. Also, PEO and PNE treatments were effective in reducing S. Heidelberg attachment on turkey skin during abuse temperature (10°C) condition for 48 h.

FIGURE 11
www.frontiersin.org

FIGURE 11. (A) Effect of PNE against S. Heidelberg attachment on turkey skin at chilling temperature (4°C) and storage at 4°C for 48 h. S. Heidelberg (4 log10 CFU/sq. inch) inoculated skin samples were treated with 0 or 1.0% PNE for 5 min at 4°C. The samples were packaged under aerobic conditions and stored at 4°C. S. Heidelberg attachment was determined by sampling at 0, 2, 24, and 48 h of storage after PEO treatments. The treatments were significantly different at P < 0.05. (B) Effect of PNE against S. Heidelberg attachment on turkey skin at chilling temperature (4°C) and storage at 10°C for 48 h. S. Heidelberg (4 log10 CFU/sq. inch) inoculated skin samples were treated with 0 or 1.0% PEO for 5 min at 4°C. The samples were packaged under aerobic conditions and stored at 10°C. S. Heidelberg attachment was determined by sampling at 0, 2, 24, and 48 h of storage after PNE treatments. The treatments were significantly different at P < 0.05.

Effect of PEO on S. Heidelberg Attachment to Turkey Skin Illustrated Using CM and SEM

As expected, S. Heidelberg was not present in the negative controls (Figures 12A, 13A, 14A, 15A). The CM and SEM revealed that the PEO treatment had no deleterious effect on turkey skin. The skin cells maintained normal shape (Figures 12B, 13B, 14B, 15B). Inoculation of skin samples with S. Heidelberg resulted in the attachment of the pathogen to both sides. The physical structure of the skin surface contributed to the firm attachment of S. Heidelberg onto the skin surface. The pathogen could penetrate deep into the crevices and feather follicles on the outer skin surface. In addition, the swelling of skin cells during the immersion process could have exposed deep channels and crevices on the skin resulting in enhanced S. Heidelberg attachment to the skin surface (Kim et al., 1996). The presence of flagella in Salmonella is also a major contributing factor for firm attachment of the pathogen to the poultry skin. Flagellar structural subunits (flgK, fliC, and fljB) and motor units (motA, motB) play a significant role in the Salmonella attachment to the poultry skin (Salehi et al., 2017).

FIGURE 12
www.frontiersin.org

FIGURE 12. Effect of PEO against S. Heidelberg attachment on turkey skin at simulated chilling temperature (4°C) – Confocal microscopy of the outer surface of skin: (A) Negative control (Turkey skin + DI water), (B) Pimenta control (Turkey skin + DI water + PEO), (C) Salmonella control (Turkey skin + DI water + S. Heidelberg) and (D) Treatment (Turkey skin + DI water + S. Heidelberg + PEO).

FIGURE 13
www.frontiersin.org

FIGURE 13. Effect of PEO against S. Heidelberg attachment on turkey skin at simulated chilling temperature (4°C) – Confocal microscopy of the inner surface of skin: (A) Negative control (Turkey skin + DI water), (B) Pimenta control (Turkey skin + DI water + PEO), (C) Salmonella control (Turkey skin + DI water + S. Heidelberg) and (D) Treatment (Turkey skin + DI water + S. Heidelberg + PEO).

FIGURE 14
www.frontiersin.org

FIGURE 14. Effect of PEO against S. Heidelberg attachment on turkey skin at simulated chilling temperature (4°C) – Scanning electron microscopy of the outer surface of skin: (A) Negative control (Turkey skin + DI water), (B) Pimenta control (Turkey skin + DI water + PEO), (C) Salmonella control (Turkey skin + DI water + S. Heidelberg) and (D) Treatment (Turkey skin + DI water + S. Heidelberg + PEO).

FIGURE 15
www.frontiersin.org

FIGURE 15. Effect of PEO against S. Heidelberg attachment on turkey skin at simulated chilling temperature (4°C) – Scanning electron microscopy of the inner surface of skin: (A) Negative control (Turkey skin + DI water), (B) Pimenta control (Turkey skin + DI water + PEO), (C) Salmonella control (Turkey skin + DI water + S. Heidelberg) and (D) Treatment (Turkey skin + DI water + S. Heidelberg + PEO).

The CM of the S. Heidelberg treated skin revealed many live S. Heidelberg cells (green rod-shaped cells) on the outer (Figure 12C) and inner (Figure 13C) surfaces of the skin. However, on the PEO treated skin, S. Heidelberg attachment was significantly less (Figures 12D, 13D) as indicated by several dead cells (red rod-shaped cells) (Figure 13D). Similarly, SEM also revealed a significant reduction of S. Heidelberg on the inner and outer surfaces of the skin in the PEO treated skin samples (Figures 14D, 15D) compared to the S. Heidelberg controls (Figures 14C, 15C). The attachment of S. Heidelberg was more on the inner surface of the skin relative to the outer surface which could be due to the strong adherence of Salmonella in the adipose tissue underneath the skin (Tan et al., 2014).

Potential Mechanisms of Action of EOs against S. Heidelberg

The active components present in the EOs elicit antimicrobial property against pathogenic microorganisms (Kollanoor Johny et al., 2008; Amalaradjou et al., 2010; Kollanoor-Johny et al., 2012a,b; Nair et al., 2014, 2015). These components include eugenol, carvacrol, thymol, cinnamaldehyde, p-cymene and a multitude of others that kill microorganisms by different modes of actions such as disruption of the cell wall, degradation of cytoplasmic membranes, alteration of membrane potential, disruption of proton motive force, and leakage of cellular contents through multiple targets in the microbial cell (Burt, 2004). However, the mode of action of essential oils could vary between Gram-negative and Gram-positive bacteria. The features of Gram negative bacterial cell such as less lipophilic nature, the presence of outer membrane and the lipopolysaccharide could make Gram negative bacteria more resistant to the effect of essential oil components (Nazzaro et al., 2013). On the other side, we have previously reported high antibacterial activity for essential oil ingredients such as trans-cinnamaldehyde and eugenol against S. Enteritidis in broiler chickens (Kollanoor-Johny et al., 2012a,b).

In the present study, the PEO treatment caused significant reduction of S. Heidelberg attached to turkey skin. The exact mechanism of action of PEO against S. Heidelberg has not been understood. However, PEO contains eugenol as a major active component having strong inhibitory activity against both Gram-negative and Gram-positive bacteria (Hyldgaard et al., 2012). The presence of eugenol might have resulted in morphological alterations of the microbial cell, including the disruption of the cell membrane, and formation cleft, and pore leading to the leakage of contents and subsequent death of microorganisms (Suzuki et al., 2014). Moreover, eugenol can down-regulate several critical genes in S. Enteritidis responsible to adhesion and invasion of cultured avian epithelial cells in vitro (Kollanoor-Johny et al., 2012a; Upadhyaya et al., 2013). More investigations are required to understand the exact mechanism of action of PEO on S. Heidelberg attached to turkey skin.

Conclusion

In the current study, we investigated the potential of PEO and PNE on S. Heidelberg attached to turkey skin in simulated scalding and chilling conditions. The highest reduction of skin attached S. Heidelberg was observed when 1.0% PEO or PNE was used for 5 min dip treatment at scalding (65°C) or chilling temperature (4°C). Although comparable S. Heidelberg reductions were obtained at both temperatures, a slightly better effect was noticed with 1% PEO at the tested scalding temperature. An antimicrobial treatment that results in 2 log or more reduction of Salmonella when applied during chilling is considered effective since Salmonella may be present on the poultry carcass in the range of <100 cells after processing (Tamblyn et al., 1997). Interestingly, no S. Heidelberg was detected in the dipping solution containing PNE and PEO treatments, although the pathogens were present in the control dipping solution. This result indicates that PEO and PNE could prevent cross-contamination or recontamination of the pathogens in case the same water is used for dipping/washing carcasses. Moreover, PEO and PNE were effective in reducing S. Heidelberg on skin during a storage period of 2 days at chilling and abuse temperatures. CM and SEM revealed a deep infiltration and attachment of S. Heidelberg in the inner and outer surfaces of the skin. Treatment with PEO reduced pathogen attachment on either side as evidenced from the CM and SEM images.

Overall, the results indicate that PEO or PNE treatments could be potential alternatives to synthetic antimicrobial agents to reduce S. Heidelberg attachment to turkey skin during poultry processing. Although the PEO was solubilized by the nanoemulsion method, the potency did not differ significantly between the PEO and PNE treatments. We are investigating the possibility of scale-up investigations with PEO by incorporating other parameters such as different Salmonella enterica serotypes of importance, exploring techniques to lower the levels of PNE and PEO for application on turkey carcasses, varying levels of organic content in the water, the age of scalding and chill water, and the effect of PEO during long-term storage. Furthermore, sensory evaluation of carcasses treated with PEO and PNE treatments must be carried out.

Author Contributions

AKJ conceived the idea and designed the experiments. DN performed all experiments and participated in the statistical analysis with AKJ. DN and AKJ jointly wrote and corrected the manuscript.

Conflict of Interest Statement

The authors declare that the research was conducted in the absence of any commercial or financial relationships that could be construed as a potential conflict of interest.

Acknowledgments

The authors would like to thank the MN Agricultural Experimentation Station project funds (state special) awarded to the PI, AKJ, for research support. They are thankful to Grant Bartel and Dr. Gail Celio at the University of Minnesota Imaging Center for their technical help with CM and SEM, respectively. They would also like to thank Dr. James Marti at the Nanotechnology Center, the University of Minnesota, for his directions on analyzing the particle size of the PNE treatments, and thank Mr. Jijo Vazhakkattu Thomas, MS student, for his help in surface plating.

References

Amalaradjou, M. A. R., Baskaran, S. A., Ramanathan, R., Kollanoor Johny, A., Charles, A. S., Valipe, S. R., et al. (2010). Enhancing the thermal destruction of Escherichia coli O157: H7 in ground beef patties by trans-cinnamaldehyde. Food Microbiol. 27, 841–844. doi: 10.1016/j.fm.2010.05.006

PubMed Abstract | CrossRef Full Text | Google Scholar

Aureli, P., Costantini, A., and Zolea, S. (1992). Antibacterial activity of some plant essential oils against Listeria monocytogenes. J. Food Prot. 55, 344–348. doi: 10.4315/0362-028X-55.5.344

CrossRef Full Text | Google Scholar

Bhargava, K., Conti, D. S., da Rocha, S. R. P., and Zhang, Y. (2015). Application of an oregano oil nanoemulsion to the control of foodborne bacteria on fresh lettuce. Food Microbiol. 47, 69–73. doi: 10.1016/j.fm.2014.11.007

PubMed Abstract | CrossRef Full Text

Burt, S. (2004). Essential oils: their antibacterial properties and potential applications in foods—a review. Int. J. Food Microbiol. 94, 223–253. doi: 10.1016/j.ijfoodmicro.2004.03.022

PubMed Abstract | CrossRef Full Text | Google Scholar

Byrd, J. A., Anderson, R. C., Callaway, T. R., Moore, R. W., Knape, K. D., Kubena, L. F., et al. (2003). Effect of experimental chlorate product administration in the drinking water on Salmonella Typhimurium contamination of broilers. Poult. Sci. 82, 1403–1406. doi: 10.1093/ps/82.9.1403

PubMed Abstract | CrossRef Full Text | Google Scholar

Carrasco, E., Morales-Rueda, A., and García-Gimeno, R. M. (2012). Cross-contamination and recontamination by Salmonella in foods: a review. Food Res. Int. 45, 545–556. doi: 10.1016/j.foodres.2011.11.004

CrossRef Full Text | Google Scholar

CDC (2011). Salmonella Heidelberg Infections Linked to Ground Turkey. Available at: https://www.cdc.gov/salmonella/2011/ground-turkey-11-10-2011.html [accessed January 15, 2017].

Google Scholar

CDC (2013). Morbidity and Mortality Weekly Report: Surveillance for Foodborne Disease Outbreaks — United States, 1998–2008. Available at: https://www.cdc.gov/mmwr/preview/mmwrhtml/ss6202a1.htm [accessed May 22, 2017].

CDC (2014a). Multistate Outbreak of Multidrug-Resistant Salmonella Heidelberg Infections Linked to Foster Farms Brand Chicken. Available at: https://www.cdc.gov/salmonella/heidelberg-10-13/ [accessed January 15, 2017].

Google Scholar

CDC (2014b). Salmonella Outbreak of Salmonella Heidelberg Infections Linked to Tyson Brand Chicken. Available at: https://www.cdc.gov/salmonella/heidelberg-01-14/ [accessed January 15, 2017].

FDA (2016). CFR - Code of Federal Regulations Title 21: Part 182 – Substances Generally Recognized as Safe: Sec. 182.20. Essential Oils, Oleoresins (Solvent-Free), and Natural Extractives (Including Distillates). Silver Spring, MD: FDA.

Foley, S. L., Lynne, A. M., and Nayak, R. (2008). Salmonella challenges: prevalence in swine and poultry and potential pathogenicity of such isolates. J. Anim. Sci. 86(Suppl. 14), E149–E162. doi: 10.2527/jas.2007-0464

PubMed Abstract | CrossRef Full Text | Google Scholar

Folster, J. P., Pecic, G., Rickert, R., Taylor, J., Zhao, S., Fedorka-Cray, P. J., et al. (2012a). Characterization of multidrug-resistant Salmonella enterica serovar Heidelberg from a ground turkey-associated outbreak in the United States in 2011. Antimicrob. Agents Chemother. 56, 3465–3466. doi: 10.1128/AAC.00201-12

PubMed Abstract | CrossRef Full Text | Google Scholar

Folster, J. P., Pecic, G., Singh, A., Duval, B., Rickert, R., Ayers, S., et al. (2012b). Characterization of extended-spectrum cephalosporin–resistant Salmonella enterica serovar Heidelberg isolated from food animals, retail meat, and humans in the United States 2009. Foodborne Pathog. Dis. 9, 638–645. doi: 10.1089/fpd.2012.1130

PubMed Abstract | CrossRef Full Text | Google Scholar

FSIS (2002). Potential Scientific Parameters that must be Considered to Establish Global Dates for Refrigerated Ready-to-Eat Foods. Available at: https://www.fsis.usda.gov/OPHS/nacmcf/2002/rep_shelflife1.htm [accessed March 11, 2017].

FSIS (2010). Compliance Guideline for Controlling Salmonella and Campylobacter in Poultry. Available at: http://www.fsis.usda.gov/PDF/Compliance_Guide_Controling_Salmonella_Campylobacter_Poultry_0510.pdf

FSIS (2014). FSIS Compliance Guide: Modernization of Poultry Slaughter Inspection: Chilling Requirements. Washington, DC: Food Safety and Inspection Service.

FSIS (2015). DRAFT FSIS Compliance Guideline for Controlling Salmonella and Campylobacter in Raw Poultry. Washington, DC: Food Safety and Inspection Service, 1–109.

Ghosh, V., Mukherjee, A., and Chandrasekaran, N. (2013). Ultrasonic emulsification of food-grade nanoemulsion formulation and evaluation of its bactericidal activity. Ultrason. Sonochem. 20, 338–344. doi: 10.1016/j.ultsonch.2012.08.010

PubMed Abstract | CrossRef Full Text | Google Scholar

GPO (2017). eCFR — Code of Federal Regulations: Subpart C—Organic Production and Handling Requirements and Subpart D—Labels, Labeling, and Market Information. Available at: http://www.ecfr.gov/cgi-bin/text-idx?SID=0a4045faa17f9676c258733eb6f1b9e7&mc=true&node=pt7.3.205&rgn=div5#sp7.3.205.c [accessed January 15, 2017].

Hyldgaard, M., Mygind, T., and Meyer, R. L. (2012). Essential oils in food preservation: mode of action, synergies, and interactions with food matrix components. Front. Microbiol. 3:12. doi: 10.3389/fmicb.2012.00012

PubMed Abstract | CrossRef Full Text | Google Scholar

Ingham, S. C., Fanslau, M. A., Burnham, G. M., Ingham, B. H., Norback, J. P., and Schaffner, D. W. (2007). Predicting pathogen growth during short-term temperature abuse of raw pork, beef, and poultry products: use of an isothermal-based predictive tool. J. Food Prot. 70, 1446–1456. doi: 10.4315/0362-028X-70.6.1446

PubMed Abstract | CrossRef Full Text | Google Scholar

Jackson, B. R., Griffin, P. M., Cole, D., Walsh, K. A., and Chai, S. J. (2013). Salmonella enterica serotypes and food commodities. Emerg. Infect. Dis. 19, 1239–1244. doi: 10.3201/eid1908.121511

PubMed Abstract | CrossRef Full Text | Google Scholar

Kim, K. Y., Frank, J. F., and Craven, S. E. (1996). Three-dimensional visualization of Salmonella attachment to poultry skin using confocal scanning laser microscopy. Lett. Appl. Microbiol. 22, 280–282. doi: 10.1111/j.1472-765X.1996.tb01161.x

PubMed Abstract | CrossRef Full Text | Google Scholar

Kollanoor Johny, A., Darre, M. J., Donoghue, A. M., Donoghue, D. J., and Venkitanarayanan, K. (2010). Antibacterial effect of trans-cinnamaldehyde, eugenol, carvacrol, and thymol on Salmonella Enteritidis and Campylobacter jejuni in chicken cecal contents in vitro. J. Appl. Poult. Res. 19, 237–244. doi: 10.3382/japr.2010-00181

CrossRef Full Text | Google Scholar

Kollanoor Johny, A., Darre, M. J., Hoagland, T. A., Schreiber, D. T., Donoghue, A. M., Donoghue, D. J., et al. (2008). Antibacterial effect of trans-cinnamaldehyde on Salmonella Enteritidis and Campylobacter jejuni in chicken drinking water. J. Appl. Poult. Res. 17, 490–497. doi: 10.3382/japr.2008-00051

CrossRef Full Text | Google Scholar

Kollanoor-Johny, A., Mattson, T., Baskaran, S. A., Amalaradjou, M. A., Babapoor, S., March, B., et al. (2012a). Reduction of Salmonella enterica serovar Enteritidis colonization in 20-day-old broiler chickens by the plant-derived compounds trans-cinnamaldehyde and eugenol. Appl. Environ. Microbiol. 78, 2981–2987. doi: 10.1128/AEM.07643-11

PubMed Abstract | CrossRef Full Text | Google Scholar

Kollanoor-Johny, A., Upadhyay, A., Baskaran, S. A., Upadhyaya, I., Mooyottu, S., Mishra, N., et al. (2012b). Effect of therapeutic supplementation of the plant compounds trans-cinnamaldehyde and eugenol on Salmonella enterica serovar Enteritidis colonization in market-age broiler chickens. J. Appl. Poult. Res. 21, 816–822. doi: 10.3382/japr.2012-00540

CrossRef Full Text | Google Scholar

Lanciotti, R., Gianotti, A., Patrignani, F., Belletti, N., Guerzoni, M., and Gardini, F. (2004). Use of natural aroma compounds to improve shelf-life and safety of minimally processed fruits. Trends Food Sci. Technol. 15, 201–208. doi: 10.1016/j.tifs.2003.10.004

CrossRef Full Text | Google Scholar

Landry, K. S., Chang, Y., McClements, D. J., and McLandsborough, L. (2014). Effectiveness of a novel spontaneous carvacrol nanoemulsion against Salmonella enterica Enteritidis and Escherichia coli O157: H7 on contaminated mung bean and alfalfa seeds. Int. J. Food Microbiol. 187, 15–21. doi: 10.1016/j.ijfoodmicro.2014.06.030

PubMed Abstract | CrossRef Full Text | Google Scholar

Lee, N. Y., Park, S. Y., Kang, I. S., and Ha, S. D. (2014). The evaluation of combined chemical and physical treatments on the reduction of resident microorganisms and Salmonella Typhimurium attached to chicken skin. Poult. Sci. 93, 208–215. doi: 10.3382/ps.2013-03536

PubMed Abstract | CrossRef Full Text | Google Scholar

Lillard, H. S. (1990). The impact of commercial processing procedures on the bacterial contamination and cross-contamination of broiler carcasses. J. Food Prot. 53, 202–207. doi: 10.4315/0362-028X-53.3.202

CrossRef Full Text | Google Scholar

Logue, C. M., Sherwood, J. S., Elijah, L. M., Olah, P. A., and Dockter, M. R. (2003). The incidence of Campylobacter spp. on processed turkey from processing plants in the midwestern United States. J. Appl. Microbiol. 95, 234–241. doi: 10.1046/j.1365-2672.2003.01969.x

PubMed Abstract | CrossRef Full Text | Google Scholar

Nagel, G. M., Bauermeister, L. J., Bratcher, C. L., Singh, M., and McKee, S. R. (2013). Salmonella and Campylobacter reduction and quality characteristics of poultry carcasses treated with various antimicrobials in a post-chill immersion tank. Int. J. Food Microbiol. 165, 281–286. doi: 10.1016/j.ijfoodmicro.2013.05.016

PubMed Abstract | CrossRef Full Text | Google Scholar

Nair, D., Thomas, J. V., and Kollanoor-Johny, A. (2016). “Propionibacterium freudenreichii reduces cecal colonization of multidrug-resistant Salmonella Heidelberg in turkey poults,” in Proceedings of the Poultry Science Association 105th Annual Meeting Abstracts (Schwean-Lardner), New Orleans, 21–22.

Nair, D. V. T., Kiess, A., Nannapaneni, R., Schilling, W., and Sharma, C. S. (2015). The combined efficacy of carvacrol and modified atmosphere packaging on the survival of Salmonella, Campylobacter jejuni and lactic acid bacteria on turkey breast cutlets. Food Microbiol. 49, 134–141. doi: 10.1016/j.fm.2015.01.010

PubMed Abstract | CrossRef Full Text | Google Scholar

Nair, D. V. T., Nannapaneni, R., Kiess, A., Schilling, W., and Sharma, C. S. (2014). Reduction of Salmonella on turkey breast cutlets by plant-derived compounds. Foodborne Pathog. Dis. 11, 981–987. doi: 10.1089/fpd.2014.1803

PubMed Abstract | CrossRef Full Text | Google Scholar

Nazzaro, F., Fratianni, F., De Martino, L., Coppola, R., and De Feo, V. (2013). Effect of essential oils on pathogenic bacteria. Pharmaceuticals 6, 1451–1474. doi: 10.3390/ph6121451

PubMed Abstract | CrossRef Full Text | Google Scholar

Nchez, M. X. S., Fluckey, W. M., Brashears, M. M., and Mckee, S. R. (2002). Antibiotic susceptibility of Campylobacter spp. and Salmonella spp. in broilers processed in air-chilled and immersion-chilled environments. J. Food Prot. 65, 948–956. doi: 10.4315/0362-028X-65.6.948

PubMed Abstract | CrossRef Full Text | Google Scholar

Poppe, C., Martin, L. C., Gyles, C. L., Reid-Smith, R., Boerlin, P., McEwen, S. A., et al. (2005). Acquisition of resistance to extended-spectrum cephalosporins by Salmonella enterica subsp. enterica serovar Newport and Escherichia coli in the turkey poult intestinal tract. Appl. Environ. Microbiol. 71, 1184–1192. doi: 10.1128/AEM.71.3.1184-1192.2005

PubMed Abstract | CrossRef Full Text | Google Scholar

Russell, S. M. (2008). Chemical residuals in the environment and on chicken carcasses associated with scalding chickens in an acidic, copper sulfate-based commercial sanitizer during poultry processing. J. Food Prot. 71, 226–230. doi: 10.4315/0362-028X-71.1.226

PubMed Abstract | CrossRef Full Text | Google Scholar

Salehi, S., Howe, K., Lawrence, M. L., Brooks, J. P., Bailey, R. H., and Karsi, A. (2017). Salmonella enterica Serovar Kentucky flagella are required for broiler skin adhesion and Caco-2 cell invasion. Appl. Environ. Microbiol. 83:e02115-16. doi: 10.1128/AEM.02115-16

PubMed Abstract | CrossRef Full Text

SAS Institute (2004). SAS/STAT 9.1 User’s Guide. Available at: http://books.google.com/books?id=2oEQyOIyCbUC&pgis=1

Seo, K., Holt, P., and Gast, R. (2000). Combined effect of antibiotic and competitive exclusion treatment on Salmonella Enteritidis fecal shedding in molted laying hens. J. Food Prot. 63, 545–548. doi: 10.4315/0362-028X-63.4.545

PubMed Abstract | CrossRef Full Text | Google Scholar

Seo, K. H., and Frank, J. F. (1999). Attachment of Escherichia coli O157:H7 to lettuce leaf surface and bacterial viability in response to chlorine treatment as demonstrated by using confocal scanning laser microscopy. J. Food Prot. 62, 3–9. doi: 10.4315/0362-028X-62.1.3

PubMed Abstract | CrossRef Full Text | Google Scholar

Shah, D. H., Paul, N. C., Sischo, W. C., Crespo, R., and Guard, J. (2017). Population dynamics and antimicrobial resistance of the most prevalent poultry-associated Salmonella serotypes. Poult. Sci. 96, 687–702. doi: 10.3382/ps/pew342

PubMed Abstract | CrossRef Full Text | Google Scholar

Sohaib, M., Anjum, F. M., Arshad, M. S., and Rahman, U. U. (2015). Postharvest intervention technologies for safety enhancement of meat and meat based products; a critical review. J. Food Sci. Technol. 53, 19–30. doi: 10.1007/s13197-015-1985-y

PubMed Abstract | CrossRef Full Text | Google Scholar

Surendran Nair, M., Lau, P., Belskie, K., Fancher, S., Chen, C.-H., Karumathil, D. P., et al. (2016). Potentiating the heat inactivation of Escherichia coli O157: H7 in ground beef patties by natural antimicrobials. Front. Microbiol. 7:15. doi: 10.3389/fmicb.2016.00015

PubMed Abstract | CrossRef Full Text | Google Scholar

Surendran-Nair, M., Kollanoor-Johny, A., Ananda-Baskaran, S., Norris, C., Lee, J.-Y., and Venkitanarayanan, K. (2016). Selenium reduces enterohemorrhagic Escherichia coli O157: H7 verotoxin production and globotriaosylceramide receptor expression on host cells. Future Microbiol. 11, 745–756. doi: 10.2217/fmb.16.16

PubMed Abstract | CrossRef Full Text | Google Scholar

Surendran Nair, M., Upadhyaya, I., Amalaradjou, M. A. R., and Venkitanarayanan, K. (2017). “Antimicrobial food additives and disinfectants,” in Foodborne Pathogens and Antibiotic Resistance, ed. O. V. Singh (Hoboken, NJ: John Wiley & Sons, Inc.), 275–301. doi: 10.1002/9781119139188.ch12

CrossRef Full Text | Google Scholar

Suzuki,É. Y., Baptista, E. B., Resende Do Carmo, A. M., Miranda Chaves, M. D. G. A., Chicourel, E. L., and Barbosa Raposo, N. R. (2014). Potential of the essential oil from Pimenta pseudocaryophyllus as an antimicrobial agent. Acta Pharm. 64, 379–385. doi: 10.2478/acph-2014-0024

PubMed Abstract | CrossRef Full Text | Google Scholar

Tamblyn, K. C., and Conner, D. E. (1997). Bactericidal activity of organic acids against Salmonella Typhimurium attached to broiler chicken skin. J. Food Prot. 60, 629–633. doi: 10.4315/0362-028X-60.6.629

CrossRef Full Text | Google Scholar

Tamblyn, K. C., Conner, D. E., and Bilgili, S. F. (1997). Utilization of the skin attachment model to determine the antibacterial efficacy of potential carcass treatments. Poult. Sci. 76, 1318–1323. doi: 10.1093/ps/76.9.1318

PubMed Abstract | CrossRef Full Text | Google Scholar

Tan, S. M., Lee, S. M., and Dykes, G. A. (2014). Fat contributes to the buffering capacity of chicken skin and meat but enhances the vulnerability of attached Salmonella cells to acetic acid treatment. Food Res. Int. 66, 417–423. doi: 10.1016/j.foodres.2014.10.007

CrossRef Full Text | Google Scholar

Upadhyaya, I., Upadhyay, A., Kollanoor-Johny, A., Darre, M., and Venkitanarayanan, K. (2013). Effect of plant derived antimicrobials on Salmonella Enteritidis adhesion to and invasion of primary chicken oviduct epithelial cells in vitro and virulence gene expression. Int. J. Mol. Sci. 14, 10608–10625. doi: 10.3390/ijms140510608

PubMed Abstract | CrossRef Full Text | Google Scholar

Venkitanarayanan, K., Kollanoor-Johny, A., Darre, M. J., Donoghue, A. M., and Donoghue, D. J. (2013). Use of plant-derived antimicrobials for improving the safety of poultry products. Poult. Sci. 92, 493–501. doi: 10.3382/ps.2012-02764

PubMed Abstract | CrossRef Full Text | Google Scholar

Waldroup, A. L. (1996). Contamination of raw poultry with pathogens. Worlds Poult. Sci. J. 52, 20–25. doi: 10.1079/Wps19960002

CrossRef Full Text | Google Scholar

WHO (2009). Microbiological Risk Assessment Series-19: Salmonella and Campylobacter in Chicken Meat. Available at: http://www.who.int/foodsafety/publications/micro/MRA19.pdf [accessed August 21, 2017].

Yang, H., Li, Y. B., and Johnson, M. G. (2001). Survival and death of Salmonella Typhimurium and Campylobacter jejuni in processing water and on chicken skin during poultry scalding and chilling. J. Food Prot. 64, 770–776. doi: 10.4315/0362-028X-64.6.770

PubMed Abstract | CrossRef Full Text | Google Scholar

Young, S. D., Olusanya, O., Jones, K. H., Liu, T., Liljebjelke, K. A., and Hofacre, C. L. (2007). Salmonella incidence in broilers from breeders vaccinated with live and killed Salmonella. J. Appl. Poult. Res. 16, 521–528. doi: 10.3382/japr.2007-00009

CrossRef Full Text

Keywords: pimenta, essential oil, Salmonella Heidelberg, turkey skin, microscopy

Citation: Nair DVT and Kollanoor Johny A (2017) Food Grade Pimenta Leaf Essential Oil Reduces the Attachment of Salmonella enterica Heidelberg (2011 Ground Turkey Outbreak Isolate) on to Turkey Skin. Front. Microbiol. 8:2328. doi: 10.3389/fmicb.2017.02328

Received: 24 May 2017; Accepted: 13 November 2017;
Published: 28 November 2017.

Edited by:

Giovanna Suzzi, Università degli Studi di Teramo, Italy

Reviewed by:

Zhao Chen, University of California, Davis, United States
Francisco Diez-Gonzalez, University of Georgia, United States
Francesca Patrignani, Università di Bologna, Italy

Copyright © 2017 Nair and Kollanoor Johny. This is an open-access article distributed under the terms of the Creative Commons Attribution License (CC BY). The use, distribution or reproduction in other forums is permitted, provided the original author(s) or licensor are credited and that the original publication in this journal is cited, in accordance with accepted academic practice. No use, distribution or reproduction is permitted which does not comply with these terms.

*Correspondence: Anup Kollanoor Johny, anupjohn@umn.edu

Disclaimer: All claims expressed in this article are solely those of the authors and do not necessarily represent those of their affiliated organizations, or those of the publisher, the editors and the reviewers. Any product that may be evaluated in this article or claim that may be made by its manufacturer is not guaranteed or endorsed by the publisher.